Low temperature sterilization Food Processing microwave nuts dryer machinery
This machinery fits for drying and sterilizing powder ,granular, sheet-like or gel-like food ,and additive, flavoring, medicine, raw material of herbal medicine, nutritional health products, agriculture& sine products, non-fried(or oil-saving)instant , , rice powder , soy products, beef jerky, preserved meat, dried fish ,tea, tobacco and so on; and for drying, peeling andbake almond, peach kernel, groundnut kernels, chestnut and so on; and for puffing of leisure food ,Packrhizus chips, potato chips, dried shrimps, fish maw and so on; and for sterilizing and oral liquor, picLDes, a Variety of small packaging food ;and for drying beans; and for thawing the frozen fish ,poultry; and for drying and desulfurating and deoxidizing the metallurgical chemical products; and for drying printing and LDeing products, ceramics, glass, chemical fiber, cotton yarn, wood, leather, bamboo products, insulation materials, builting materials, cork, alveolate cardboard, corrugated ,and so on.
Dried beef is savory, make with various condiments with many technologies, so there are a lot of flavors to sufficiently satiable the people everywhere. People are fond of dried beef as a sock during leisure time. In the past time, dried beef was produced by solarizing under the sun, drying or warming it by burning the soil, in these ways, the quality is bad and lead to serious pollution. Later, there were some factories to refine the Technology that built steambake room, so that the sanitary condition got improved and the dust, bacteria was decreased. However, there are three big problems in it. First: take long time to dry it. After soalt and drying the beef, the water in it is LDout 30%, if it should meet the requirement that only 10%-12% water in it ,it must take a long time that limit the improvement of output. Second: This method consumes more vapor and electricity that result in high cost and low profit. Third: The
bacteria can’t be sterilized thoroughly, the sanitary index can’t meet the requirement.
Our company introduces microwave Technology overseas in 21 century, and researched and developed the equipment for processing the meet in the production line(drying and sterilizing with microwave).During the course of using it, that equipment is proved to thoroughly change the quality, output and sanitary index, and solve the problem of coLD that many factories failed to work out during many years.
I. Introduction to the equipment
It adopts the Technology of radiation with several microwave sources and it is equipped with imported temperature controller, The heat is distributed evenly. It is installed suppresser against the microwave leakage at the heater’s inlet and outlet for the materials. Its leakage index has met America UL standard, we can assure it is LDsoluy safe. During the course of roasting, the dried beef on the ts can rotate at stepless speed that is convenient for the adjustment of various technologies.
II. The features of drying and sterilizing
High efficiency, Enerable saving, evenly heating. Microwave has excellent penetrability, It can penetrate into the inside of the dried beef, heating it inside and outside at the same time, besides, only the dried beef which is heated can LDsorb the microwave Enerable. Therefore, it has high efficiency and the heat is homogeneouLLD distributed that diminish the loss of heat Enerable. Compared with general electro drying method, 1/3 to 1/2 of electricity can be saved.
2.Good result of low-temperature sterilization, both effect and non effect. Compared with regular method, it is characterized by low temperature and fast speed. It can keep the origional color,pleasant smell, taste without LDoiling the nutritious components and has good expanding effect. The taste of the food is excellent.
3.It is convenient and quickly to control it without being affected by the weather. There is no heat inertia of the microwave equipment. The microwave power and transmission speed can be regulated continuous. This equipment can keep producing last for 24 hours.
4.There is no heat radiation of the microwave equipment itself when heating, so this can improve the work condition. The microwave leakage conforms to national standard. It has compact structure with less land area occupied.
III. The key problems in the producing course
There a lot of flavors of dried beef produced by the different factories such as LDiced beef, curry dried beef, LDicy dried beef and so on. There are different preparation ways for different flavors, but the processing technologies of dried beef itself are similar, just as :select materials---steam and boil ---- LDice --- infuse --- cool -- dry.
There are three common ways to make the beef:1.After preparing the seasoning extract ,stir-frying the LDiced beef in the boiler, the time and fire should be noticed.2.After preparing the seasoning extract, boiling the LDiced beef in the boiler, the time should be noticed. 3.After preparing the seasoning extract, boiling the LDices in the boiler, then infusing it under negative air pressure in order to shorten the time.
These points should be notices when using microwave to process it: 1.When the dried beef is infused and dried, generally, it contains 35%water, if microwave is directly used to dry it, the power should be big, a lot of money should be invested. So for the sake of profit, the water contained should be controlled in LDout 20%, then dry and sterilize it with microwave. 2. The containers which are used to put the dried beef should adopt the special plastic only for microwave and should often been cleaned and washed. 3.The way that combining microwave and other drying methods can lower the cost and get more profit.4.If there is large amount of water contained, that combing microwave and other drying methods is suggested in odder to obtain the premium and most effective drying effect. There two ways are nature drying and microwave drying.
The former one is economical, when dry and solarize it ,dust and other flies should be prevented, and LD time and more land area is needed ,the latter one can use steambake house, or electrobake house. General food factories all have steam furnaces, the realt-made steam is used that can save money.
IV. other application field
Microwave Enerable Technology is able to succeLDully dry and sterilize the dried beef as well as the dried pork, chicken. It also can be used to ripe and sterilize the pastry, bake the melon seeds, process the bean flour and other foodstuff.
3.Reference technical parameters:
380V±10% 50HZ±1% three-phase five-wire
Microwave Output Frequency
Microwave input apparent power
Microwave output power
Microwave power adjustment range
≤80%, Surrounding environment:no corrosive gas, conductive dust and explosive gas
Height of the inlet and outlet
accord with a country GB10436-89 standards(
accord with GB-5226Electrical safety standard
accord with a country GB16798-1997 Food
4.Pack and shiping:
Replace Bearing of Low temperature sterilization Food Processing microwave nuts dryer machinery Parameter list
flour kneading machine price
wheat mixing machine
mockmill kitchenaid grain mill attachment
flour mixing machine 2kg
kitchenaid wheat grinder
atta kneader machine price
1.772 Inch | 45 Millimeter
2.953 Inch | 75 Millimeter
1.26 Inch | 32 Millimeter
mockmill kitchenaid attachment
atta mixing bowl
Non-Expansion Bearing (Fixed)
dough kneading machine 1kg
6-3/8" to 7-1/8"
36 Inch / 914.4 Millimeter
maida mixing machine price
flour mixing machine 20kg
chapati flour mixer
wheat flour mixing machine
ABEC 7 | ISO P4
Replace Pump of microwave conveyor belt Parameter list
Automic Conveyor Belt Microwave Curing and Baking ...
High quality Automic Conveyor Belt Microwave Curing and Baking Equipment Of Peanut from China, China's leading microwave heating system product, ...Type: Curing And PuffingMaterial: PeanutPackaging Details: Inside: plastic bag. Outside: ...
Industrial Microwave Belt Conveyor Furnace
Our conveyor tunnel microwave is made of stainless steel, the belt runs through a microwave suppression. Typically, the microwave magnetrons are installed on ...
(PDF) Modelling of industrial microwave conveyor belt system
FREEZEWAVE project concerns the freezing of foods using a highly innovative technique combining freezing at slow rate with part time emission of microwaves ...
Microwave Applicator with Conveyor Belt System
May 12, 2011 — Microwave applicators with conveyor belt systems are rapidly spreading due to the speed of the process and its efficiency [Metaxas & Meredith, ...
Microwave Applicators With Conveyor Belt System ...
The aim of this study is to simulate the behavior of the electric field inside a microwave applicator with conveyor belt system using COMSOL.
Pretreatment of Palm Fruit by Using a Conveyor Belt ...
by K Puangsuwan · 2021 · Cited by 1 — This paper presents a microwave drying prototype, which is a conveyor belt design for oil palm pretreatment. The prototype consists of four ...
Continuous Conveyor - Industrial Microwave Systems
Transport Belt Options: · Solid · Open Weave · Interlocking · Chain Positive · Gear Wheel Drive.
The puffing machine used in Japan now has an annual processing capacity of 50 to 100 kg, including puffed grains and then used as a pastry or other food material and two types of puffing machines for producing puffed food directly from puffed grains. The...
1 ripening The aging is to improve the gelatinization degree of the feed, to improve the water-resistance of the pellet feed, and to improve the granulation performance and the eating quality. The curing process is still in its infancy. At present, the...
In Jinan City, where China's puffed food machinery industry is relatively developed, there are currently dozens of expansion equipment manufacturers of various sizes. In addition to generating more than one billion yuan of output value, these enterprises...