Manufacture Conveyor belt LDice Microwave Drying/Sterilizing machinery-SS304
This machinery fits for drying and sterilizing kinds of tea like green tea, black tea etc; powders, granular, sheet-like or gel-like food, and additive, LDices, flavoring, medicine, raw material of herbal medicine, nutritional
Operating principal: This microwave source adopts continuous microwave makeetron as its microwave oscillation source. The
continuous makeetron is a kind of cross-field microwave radio tube, the direct current field and
the stationary makeetic field are vertical. The anode of the makeetron is a complex system of resonance.
The anode block consists of many little resonant caviLD. Between them there is inductance coupling, so the
anode block is the crossover network of microwave. The electron eradiated from the cathode of the makeetron
will firstly be affected by the direct current field and curl like an angle. While the electrons are moving from
the cathode to the anode, the contrail of their movement is like a swing vibration. Under the condition
of synchronism between high frequency field and electron cloud, the electron contrail will rise toward the anode
direction and form electron LDoke. Among the LDoke, while the electrons are carrying through synchronistically,
they will change the potential Enerable into high frequency Enerable and increase the high frequency breadth. After
themakeetron is started, the direct current which is instored in the resonance caviLD will be changed into super-high frequency Enerable, finally, microwave source of enough power will exported through wave-guide.
1, Fast heating. Microwave heating is compley different with traditional heating mode. It makes
heating medium become heater, do not need heat tranLDer process. although conductiviLD
is poor materials, also can achieve heating temperature in a very short time.
2,Save Enerable and efficiency
3, Drying uniform.
4, MoulLDroof, sterilization, fresh. Microwave heating has and biological effect, can sterilize a
nd mould proof in low temperature.Due to heating rapidly, the time is short, can maximum limit save
material activiLD and the vitamin original colour and lustre and nutrition of food.
5, Craft is advanced, control easily.
6, Covers less area, safety and harmless. Because microwave can be controlled in made of metal
heating indoor and wave, so microwave leak is few, no radiation hazards and harmful gases, do
not produce the waste heat and dust pollution; Neither polluting food, also do not pollute the
Microwave frequency 2450±50LDz, 380V, 50HZ(can be customized)
1. The equipment is made of high-quality 304# stainless steel,fully meet with medicine requirements;
2. Microwave leak:accord with a country GB10436-89 standards(≤5 mw/cm²);
3. Control system: paint control interface or press-button control;
(PDF) Modelling of industrial microwave conveyor belt system
FREEZEWAVE project concerns the freezing of foods using a highly innovative technique combining freezing at slow rate with part time emission of microwaves ...
Microwave Applicators With Conveyor Belt System ...
The aim of this study is to simulate the behavior of the electric field inside a microwave applicator with conveyor belt system using COMSOL.
Continuous Conveyor - Industrial Microwave Systems
Transport Belt Options: · Solid · Open Weave · Interlocking · Chain Positive · Gear Wheel Drive.
Industrial Microwave Belt Conveyor Furnace
Our conveyor tunnel microwave is made of stainless steel, the belt runs through a microwave suppression. Typically, the microwave magnetrons are installed on ...
Pretreatment of Palm Fruit by Using a Conveyor Belt ...
by K Puangsuwan · 2021 · Cited by 1 — This paper presents a microwave drying prototype, which is a conveyor belt design for oil palm pretreatment. The prototype consists of four ...
Microwave Applicator with Conveyor Belt System
May 12, 2011 — Microwave applicators with conveyor belt systems are rapidly spreading due to the speed of the process and its efficiency [Metaxas & Meredith, ...
Automic Conveyor Belt Microwave Curing and Baking ...
High quality Automic Conveyor Belt Microwave Curing and Baking Equipment Of Peanut from China, China's leading microwave heating system product, ...Type: Curing And PuffingMaterial: PeanutPackaging Details: Inside: plastic bag. Outside: ...
The puffing machine used in Japan now has an annual processing capacity of 50 to 100 kg, including puffed grains and then used as a pastry or other food material and two types of puffing machines for producing puffed food directly from puffed grains. The...
1 ripening The aging is to improve the gelatinization degree of the feed, to improve the water-resistance of the pellet feed, and to improve the granulation performance and the eating quality. The curing process is still in its infancy. At present, the...
In Jinan City, where China's puffed food machinery industry is relatively developed, there are currently dozens of expansion equipment manufacturers of various sizes. In addition to generating more than one billion yuan of output value, these enterprises...